2004 Mitsubishi L200 MOT pass rate, common failures & what to check

In 2025, 56.0% of Mitsubishi L200s first used in 2004 passed their MOT first time, against 57.8% for all cars first used in 2004. Across 6,840 L200 first tests from 2023 to 2025, the most common failure areas were lamps and electrical equipment, suspension and body, chassis and structure.

This page analyses first MOT tests for Mitsubishi L200s first used in 2004 (all trims grouped): 2021 to 2025 for the pass-rate trend, and 2023 to 2025 for the failure and advisory analysis — plus what is worth checking before you buy one.

Data: DVSA anonymised MOT tests to December 2025 · Calculated by SortedCars · Updated October 2026

Passed first time, 2025
56.0%
of 1,792 first tests; all cars first used in 2004: 57.8%. Fixed-at-the-test counts as a fail
Tests analysed
6,840
first tests, 2023–2025; 1,792 in 2025
Clean pass, 2025
16.8%
of 1,792 first tests in 2025, passed with no advisory and no minor defect recorded
Typical mileage, tested in 2025
121,500
middle half: 95,000–149,000 miles; all cars first used in 2004: 103,500

How the 2004 Mitsubishi L200 MOT pass rate has changed

Share of first tests passed in each year, L200s first used in 2004 against all cars first used in 2004 (any make or fuel; not adjusted for mileage, fuel or use). In 2025 the L200 figure was in line with the all-cars figure.

2004 L200All cars first used in 2004
50%60%20212022202320242025Test year (first tests)All cars first used in 2004, test year 2021: 53.9%All cars first used in 2004, test year 2022: 55.2%All cars first used in 2004, test year 2023: 56%All cars first used in 2004, test year 2024: 56.4%All cars first used in 2004, test year 2025: 57.8%2004 L200, test year 2021: 53.8%2004 L200, test year 2022: 54.3%2004 L200, test year 2023: 55%2004 L200, test year 2024: 55.4%2004 L200, test year 2025: 56%57.8%56%
View this chart as a table
Test year2004 L200All cars first used 2004L200 first tests
202153.8%53.9%4,127
202254.3%55.2%3,491
202355.0%56.0%2,819
202455.4%56.4%2,229
202556.0%57.8%1,792

Common 2004 Mitsubishi L200 MOT failures

Share of the 3,050 failed first tests (2023–2025) with at least one failure in each area. A test can fail in more than one area, so the shares add up to more than 100%.

Lamps, reflectors and electrical equipment60.4%
Suspension38.2%
Body, chassis, structure37.7%
Brakes30.9%
Visibility19.1%
Steering18.9%
Noise, emissions and leaks14.6%
Tyres8.5%

Most common failure items

DVSA failure itemShare of failed first testsTests
Position lamp: not working20.3%618
Rigid brake pipes: excessively corroded12.9%392
Drive shaft joints: constant velocity boot split or insecure, no longer prevents the ingress of dirt11.3%344
Rear fog lamp: not working10.9%331
Stop lamp: not working10.6%323

Item names are DVSA’s own wording. 2023–2025 combined.

What to check on a 2004 Mitsubishi L200 before buying

The three areas where failed first tests most often had a fault, 2023–2025.

  1. Lamps and electrics. Ask someone to watch while you work the brake lights, indicators, sidelights, dipped and main beam, and the number-plate lamps.
  2. Suspension. Worth looking behind the front wheels with a torch at the coil springs, and listening for knocks over bumps on the test drive.
  3. Body and underside. Worth looking underneath with a torch at the sills, floor and mountings for corrosion, and at the rubber boots on the drive shafts for splits.

Common 2004 Mitsubishi L200 MOT advisories

Advisories are points the tester noted that did not fail the car. Most common on 2004 L200s, as a share of all 6,840 first tests, 2023–2025.

DVSA advisory itemShare of first testsTests
Engine oil leaks: leak, but not excessive31.0%2,122
Rigid brake pipes: corroded, covered in grease or other material30.2%2,063
Wheel bearings: has slight play13.8%944
Tread depth: worn close to legal limit/worn on edge10.9%746
Chassis condition: is corroded but structural rigidity is not significantly reduced10.1%693

Questions about the 2004 Mitsubishi L200 MOT

What is the MOT pass rate of a 2004 Mitsubishi L200?

In 2025, 56.0% of L200s first used in 2004 passed their MOT first time, against 57.8% for all cars first used in 2004. A car fixed during the test counts as a fail.

What does a 2004 L200 most often fail its MOT on?

Lamps and electrical equipment (in 60.4% of failed first tests, 2023–2025), suspension (38.2%) and body, chassis and structure (37.7%). The single most common item was “Position lamp: not working” (20.3%).

How often does a 2004 Mitsubishi L200 fail its MOT?

In 2025, 44.0% of first tests on L200s first used in 2004 did not pass first time: 37.6% failed, and a further 6.4% had a fault fixed during the test (counted as a fail here). Across 2023–2025, 3,050 of 6,840 first tests did not pass first time.

What are the most common 2004 Mitsubishi L200 MOT advisories?

“Engine oil leaks: leak, but not excessive” (on 31.0% of first tests, 2023–2025), “Rigid brake pipes: corroded, covered in grease or other material” (30.2%), “Wheel bearings: has slight play” (13.8%), “Tread depth: worn close to legal limit/worn on edge” (10.9%) and “Chassis condition: is corroded but structural rigidity is not significantly reduced” (10.1%).

Is a 2004 Mitsubishi L200 reliable?

An MOT pass rate shows what failed at the test, not how reliable a car is. For this group of cars the first-time pass rate went from 53.8% in 2021 to 56.0% in 2025. For one particular car, its own MOT history matters more than the average.

Other cars first used in 2004

The most-tested cars from the same year. Each page uses the same method.

2004 Ford Fiesta MOT statistics · 2004 MINI Hatch MOT statistics · 2004 Ford Focus MOT statistics · 2004 Toyota Yaris MOT statistics · 2004 Volkswagen Polo MOT statistics

How the 2004 Mitsubishi L200 MOT data is calculated

Every number on this page is calculated by SortedCars from DVSA’s anonymised MOT test data for Great Britain, 2021–2025. “2004 L200” means a Mitsubishi L200 whose date of first use falls in 2004 (53, 04 and 54 plates), all trims grouped. Class 4 vehicles, first tests only — retests are not counted. Pass rate = passed ÷ all first tests; a car with a fault fixed during the test (PRS) counts as a fail. Our national first-test pass rate matches DVSA’s published figure (table DVSA/MOT/01) to within 0.04 points in every year. Clean pass = passed with no advisory and no minor defect recorded. Mileage is the reading recorded at the test. Comparisons are with all cars first used in 2004, any make or fuel, and are not adjusted for mileage, fuel or use. Failure and advisory item names are DVSA’s own wording. No figure is shown for fewer than 500 tests; an item is shown only if it appears on at least 50 tests and 1% of the base. Pass rates describe a group of cars, not one car: a well-kept example can pass and a neglected one can fail. This page is general information, not advice about any particular vehicle; always have a used car inspected before you buy. SortedCars is not affiliated with or endorsed by DVSA. You can check any car’s MOT history free on the official service: gov.uk/check-mot-history. Contains public sector information licensed under the Open Government Licence v3.0.