1998 Toyota Hilux MOT pass rate, common failures & what to check

In 2025, 56.3% of Toyota Hilux cars first used in 1998 passed their MOT first time, against 65.6% for all cars first used in 1998. Across 1,951 Hilux first tests from 2023 to 2025, the most common failure areas were lamps and electrical equipment, suspension and brakes.

This page analyses first MOT tests for Toyota Hilux cars first used in 1998 (all trims grouped): 2021 to 2025 for the pass-rate trend, and 2023 to 2025 for the failure and advisory analysis — plus what is worth checking before you buy one.

Data: DVSA anonymised MOT tests to December 2025 · Calculated by SortedCars · Updated October 2026

Passed first time, 2025
56.3%
of 570 first tests; all cars first used in 1998: 65.6%. Fixed-at-the-test counts as a fail
Tests analysed
1,951
first tests, 2023–2025; 570 in 2025
Clean pass, 2025
21.2%
of 570 first tests in 2025, passed with no advisory and no minor defect recorded
Typical mileage, tested in 2025
157,500
middle half: 125,000–203,000 miles; all cars first used in 1998: 98,000

How the 1998 Toyota Hilux MOT pass rate has changed

Share of first tests passed in each year, Hilux cars first used in 1998 against all cars first used in 1998 (any make or fuel; not adjusted for mileage, fuel or use). In 2025 the Hilux figure was 9.3 points lower.

1998 HiluxAll cars first used in 1998
50%60%70%20212022202320242025Test year (first tests)All cars first used in 1998, test year 2021: 60.7%All cars first used in 1998, test year 2022: 62.4%All cars first used in 1998, test year 2023: 64%All cars first used in 1998, test year 2024: 64.9%All cars first used in 1998, test year 2025: 65.6%1998 Hilux, test year 2021: 54%1998 Hilux, test year 2022: 53.2%1998 Hilux, test year 2023: 55.8%1998 Hilux, test year 2024: 58.9%1998 Hilux, test year 2025: 56.3%65.6%56.3%
View this chart as a table
Test year1998 HiluxAll cars first used 1998Hilux first tests
202154.0%60.7%819
202253.2%62.4%772
202355.8%64.0%720
202458.9%64.9%661
202556.3%65.6%570

Common 1998 Toyota Hilux MOT failures

Share of the 839 failed first tests (2023–2025) with at least one failure in each area. A test can fail in more than one area, so the shares add up to more than 100%.

Lamps, reflectors and electrical equipment52.0%
Suspension41.8%
Brakes40.3%
Body, chassis, structure39.1%
Visibility18.2%
Seat belts and supplementary restraint systems14.7%
Steering14.5%
Noise, emissions and leaks12.8%

Most common failure items

DVSA failure itemShare of failed first testsTests
Rear fog lamp: not working21.0%176
Prescribed areas: prescribed area strength or continuity significantly reduced11.3%95
Drive shaft joints: constant velocity boot split or insecure, no longer prevents the ingress of dirt11.2%94
Position lamp: not working11.2%94
Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength10.8%91

Item names are DVSA’s own wording. 2023–2025 combined.

What to check on a 1998 Toyota Hilux before buying

The three areas where failed first tests most often had a fault, 2023–2025.

  1. Lamps and electrics. Ask someone to watch while you work the brake lights, indicators, sidelights, dipped and main beam, and the number-plate lamps.
  2. Suspension. Worth looking behind the front wheels with a torch at the coil springs, and listening for knocks over bumps on the test drive.
  3. Brakes. Worth looking at the discs and pads through the wheel spokes for scoring and a worn lip, and noticing on the test drive whether the car pulls to one side or the pedal feels long.

Common 1998 Toyota Hilux MOT advisories

Advisories are points the tester noted that did not fail the car. Most common on 1998 Hilux cars, as a share of all 1,951 first tests, 2023–2025.

DVSA advisory itemShare of first testsTests
Wheel bearings: has slight play17.5%342
Rigid brake pipes: corroded, covered in grease or other material17.5%341
Engine oil leaks: leak, but not excessive14.4%281
Tread depth: worn close to legal limit/worn on edge9.7%189
Chassis condition: is corroded but structural rigidity is not significantly reduced7.5%146

Questions about the 1998 Toyota Hilux MOT

What is the MOT pass rate of a 1998 Toyota Hilux?

In 2025, 56.3% of Hilux cars first used in 1998 passed their MOT first time, against 65.6% for all cars first used in 1998. A car fixed during the test counts as a fail.

What does a 1998 Hilux most often fail its MOT on?

Lamps and electrical equipment (in 52.0% of failed first tests, 2023–2025), suspension (41.8%) and brakes (40.3%). The single most common item was “Rear fog lamp: not working” (21.0%).

How often does a 1998 Toyota Hilux fail its MOT?

In 2025, 43.7% of first tests on Hilux cars first used in 1998 did not pass first time: 38.2% failed, and a further 5.4% had a fault fixed during the test (counted as a fail here). Across 2023–2025, 839 of 1,951 first tests did not pass first time.

What are the most common 1998 Toyota Hilux MOT advisories?

“Wheel bearings: has slight play” (on 17.5% of first tests, 2023–2025), “Rigid brake pipes: corroded, covered in grease or other material” (17.5%), “Engine oil leaks: leak, but not excessive” (14.4%), “Tread depth: worn close to legal limit/worn on edge” (9.7%) and “Chassis condition: is corroded but structural rigidity is not significantly reduced” (7.5%).

Is a 1998 Toyota Hilux reliable?

An MOT pass rate shows what failed at the test, not how reliable a car is. For this group of cars the first-time pass rate went from 54.0% in 2021 to 56.3% in 2025. For one particular car, its own MOT history matters more than the average.

Other cars first used in 1998

The most-tested cars from the same year. Each page uses the same method.

1998 Volkswagen Transporter MOT statistics · 1998 Land Rover Defender MOT statistics · 1998 Mazda MX-5 MOT statistics · 1998 BMW Z3 MOT statistics · 1998 BMW 3 Series MOT statistics

How the 1998 Toyota Hilux MOT data is calculated

Every number on this page is calculated by SortedCars from DVSA’s anonymised MOT test data for Great Britain, 2021–2025. “1998 Hilux” means a Toyota Hilux whose date of first use falls in 1998 (R and S plates), all trims grouped. Class 4 vehicles, first tests only — retests are not counted. Pass rate = passed ÷ all first tests; a car with a fault fixed during the test (PRS) counts as a fail. Our national first-test pass rate matches DVSA’s published figure (table DVSA/MOT/01) to within 0.04 points in every year. Clean pass = passed with no advisory and no minor defect recorded. Mileage is the reading recorded at the test. Comparisons are with all cars first used in 1998, any make or fuel, and are not adjusted for mileage, fuel or use. Failure and advisory item names are DVSA’s own wording. No figure is shown for fewer than 500 tests; an item is shown only if it appears on at least 50 tests and 1% of the base. Pass rates describe a group of cars, not one car: a well-kept example can pass and a neglected one can fail. This page is general information, not advice about any particular vehicle; always have a used car inspected before you buy. SortedCars is not affiliated with or endorsed by DVSA. You can check any car’s MOT history free on the official service: gov.uk/check-mot-history. Contains public sector information licensed under the Open Government Licence v3.0.