2005 Toyota Hiace MOT pass rate, common failures & what to check

In 2025, 65.5% of Toyota Hiaces first used in 2005 passed their MOT first time, against 57.6% for all cars first used in 2005. Across 3,652 Hiace first tests from 2023 to 2025, the most common failure areas were lamps and electrical equipment, suspension and brakes.

This page analyses first MOT tests for Toyota Hiaces first used in 2005 (all trims grouped): 2021 to 2025 for the pass-rate trend, and 2023 to 2025 for the failure and advisory analysis — plus what is worth checking before you buy one.

Data: DVSA anonymised MOT tests to December 2025 · Calculated by SortedCars · Updated October 2026

Passed first time, 2025
65.5%
of 1,081 first tests; all cars first used in 2005: 57.6%. Fixed-at-the-test counts as a fail
Tests analysed
3,652
first tests, 2023–2025; 1,081 in 2025
Clean pass, 2025
21.7%
of 1,081 first tests in 2025, passed with no advisory and no minor defect recorded
Typical mileage, tested in 2025
151,000
middle half: 114,000–194,500 miles; all cars first used in 2005: 105,500

How the 2005 Toyota Hiace MOT pass rate has changed

Share of first tests passed in each year, Hiaces first used in 2005 against all cars first used in 2005 (any make or fuel; not adjusted for mileage, fuel or use). In 2025 the Hiace figure was 7.9 points higher.

2005 HiaceAll cars first used in 2005
50%60%70%20212022202320242025Test year (first tests)All cars first used in 2005, test year 2021: 54.6%All cars first used in 2005, test year 2022: 55.7%All cars first used in 2005, test year 2023: 56.3%All cars first used in 2005, test year 2024: 56.5%All cars first used in 2005, test year 2025: 57.6%2005 Hiace, test year 2021: 65%2005 Hiace, test year 2022: 63.6%2005 Hiace, test year 2023: 65%2005 Hiace, test year 2024: 64.1%2005 Hiace, test year 2025: 65.5%65.5%57.6%
View this chart as a table
Test year2005 HiaceAll cars first used 2005Hiace first tests
202165.0%54.6%1,602
202263.6%55.7%1,535
202365.0%56.3%1,384
202464.1%56.5%1,187
202565.5%57.6%1,081

Common 2005 Toyota Hiace MOT failures

Share of the 1,284 failed first tests (2023–2025) with at least one failure in each area. A test can fail in more than one area, so the shares add up to more than 100%.

Lamps, reflectors and electrical equipment48.3%
Suspension40.6%
Brakes26.9%
Visibility21.1%
Body, chassis, structure21.0%
Noise, emissions and leaks12.9%
Tyres10.0%
Seat belts and supplementary restraint systems4.9%

Most common failure items

DVSA failure itemShare of failed first testsTests
Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength19.2%247
Position lamp: not working17.5%225
Stop lamp: not working14.8%190
Wipers: does not clear the windscreen effectively10.6%136
Rigid brake pipes: excessively corroded10.2%131

Item names are DVSA’s own wording. 2023–2025 combined.

What to check on a 2005 Toyota Hiace before buying

The three areas where failed first tests most often had a fault, 2023–2025.

  1. Lamps and electrics. Ask someone to watch while you work the brake lights, indicators, sidelights, dipped and main beam, and the number-plate lamps.
  2. Suspension. Worth looking behind the front wheels with a torch at the coil springs, and listening for knocks over bumps on the test drive.
  3. Brakes. Worth looking at the discs and pads through the wheel spokes for scoring and a worn lip, and noticing on the test drive whether the car pulls to one side or the pedal feels long.

Common 2005 Toyota Hiace MOT advisories

Advisories are points the tester noted that did not fail the car. Most common on 2005 Hiaces, as a share of all 3,652 first tests, 2023–2025.

DVSA advisory itemShare of first testsTests
Rigid brake pipes: corroded, covered in grease or other material21.4%780
Coil spring: corroded13.4%490
Tread depth: worn close to legal limit/worn on edge12.9%470
Wheel bearings: has slight play11.4%415
Component mounting prescribed areas: prescribed area is corroded but not considered excessive8.1%294

Questions about the 2005 Toyota Hiace MOT

What is the MOT pass rate of a 2005 Toyota Hiace?

In 2025, 65.5% of Hiaces first used in 2005 passed their MOT first time, against 57.6% for all cars first used in 2005. A car fixed during the test counts as a fail.

What does a 2005 Hiace most often fail its MOT on?

Lamps and electrical equipment (in 48.3% of failed first tests, 2023–2025), suspension (40.6%) and brakes (26.9%). The single most common item was “Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength” (19.2%).

How often does a 2005 Toyota Hiace fail its MOT?

In 2025, 34.5% of first tests on Hiaces first used in 2005 did not pass first time: 28.8% failed, and a further 5.7% had a fault fixed during the test (counted as a fail here). Across 2023–2025, 1,284 of 3,652 first tests did not pass first time.

What are the most common 2005 Toyota Hiace MOT advisories?

“Rigid brake pipes: corroded, covered in grease or other material” (on 21.4% of first tests, 2023–2025), “Coil spring: corroded” (13.4%), “Tread depth: worn close to legal limit/worn on edge” (12.9%), “Wheel bearings: has slight play” (11.4%) and “Component mounting prescribed areas: prescribed area is corroded but not considered excessive” (8.1%).

Is a 2005 Toyota Hiace reliable?

An MOT pass rate shows what failed at the test, not how reliable a car is. For this group of cars the first-time pass rate went from 65.0% in 2021 to 65.5% in 2025. For one particular car, its own MOT history matters more than the average.

Other cars first used in 2005

The most-tested cars from the same year. Each page uses the same method.

2005 Ford Fiesta MOT statistics · 2005 MINI Hatch MOT statistics · 2005 Ford Focus MOT statistics · 2005 Volkswagen Golf MOT statistics · 2005 Toyota Yaris MOT statistics

How the 2005 Toyota Hiace MOT data is calculated

Every number on this page is calculated by SortedCars from DVSA’s anonymised MOT test data for Great Britain, 2021–2025. “2005 Hiace” means a Toyota Hiace whose date of first use falls in 2005 (54, 05 and 55 plates), all trims grouped. Class 4 vehicles, first tests only — retests are not counted. Pass rate = passed ÷ all first tests; a car with a fault fixed during the test (PRS) counts as a fail. Our national first-test pass rate matches DVSA’s published figure (table DVSA/MOT/01) to within 0.04 points in every year. Clean pass = passed with no advisory and no minor defect recorded. Mileage is the reading recorded at the test. Comparisons are with all cars first used in 2005, any make or fuel, and are not adjusted for mileage, fuel or use. Failure and advisory item names are DVSA’s own wording. No figure is shown for fewer than 500 tests; an item is shown only if it appears on at least 50 tests and 1% of the base. Pass rates describe a group of cars, not one car: a well-kept example can pass and a neglected one can fail. This page is general information, not advice about any particular vehicle; always have a used car inspected before you buy. SortedCars is not affiliated with or endorsed by DVSA. You can check any car’s MOT history free on the official service: gov.uk/check-mot-history. Contains public sector information licensed under the Open Government Licence v3.0.