1997 Ford Transit MOT pass rate, common failures & what to check

In 2025, 65.0% of Ford Transits first used in 1997 passed their MOT first time, against 66.9% for all cars first used in 1997. Across 2,360 Transit first tests from 2023 to 2025, the most common failure areas were lamps and electrical equipment, suspension and body, chassis and structure.

This page analyses first MOT tests for Ford Transits first used in 1997 (all trims grouped): 2021 to 2025 for the pass-rate trend, and 2023 to 2025 for the failure and advisory analysis — plus what is worth checking before you buy one.

Data: DVSA anonymised MOT tests to December 2025 · Calculated by SortedCars · Updated October 2026

Passed first time, 2025
65.0%
of 746 first tests; all cars first used in 1997: 66.9%. Fixed-at-the-test counts as a fail
Tests analysed
2,360
first tests, 2023–2025; 746 in 2025
Clean pass, 2025
24.1%
of 746 first tests in 2025, passed with no advisory and no minor defect recorded
Typical mileage, tested in 2025
98,000
middle half: 74,000–134,500 miles; all cars first used in 1997: 100,000

How the 1997 Ford Transit MOT pass rate has changed

Share of first tests passed in each year, Transits first used in 1997 against all cars first used in 1997 (any make or fuel; not adjusted for mileage, fuel or use). In 2025 the Transit figure was in line with the all-cars figure.

1997 TransitAll cars first used in 1997
60%70%20212022202320242025Test year (first tests)All cars first used in 1997, test year 2021: 61.4%All cars first used in 1997, test year 2022: 63.3%All cars first used in 1997, test year 2023: 64.5%All cars first used in 1997, test year 2024: 65.4%All cars first used in 1997, test year 2025: 66.9%1997 Transit, test year 2021: 61.8%1997 Transit, test year 2022: 61.5%1997 Transit, test year 2023: 62.5%1997 Transit, test year 2024: 60.7%1997 Transit, test year 2025: 65%66.9%65%
View this chart as a table
Test year1997 TransitAll cars first used 1997Transit first tests
202161.8%61.4%947
202261.5%63.3%891
202362.5%64.5%837
202460.7%65.4%777
202565.0%66.9%746

Common 1997 Ford Transit MOT failures

Share of the 880 failed first tests (2023–2025) with at least one failure in each area. A test can fail in more than one area, so the shares add up to more than 100%.

Lamps, reflectors and electrical equipment45.5%
Suspension41.2%
Body, chassis, structure39.8%
Brakes29.1%
Visibility23.1%
Seat belts and supplementary restraint systems10.2%
Noise, emissions and leaks10.0%
Tyres9.7%

Most common failure items

DVSA failure itemShare of failed first testsTests
Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength25.7%226
Wipers: does not clear the windscreen effectively9.7%85
Integral vehicle structure condition: corroded to the extent that the rigidity of the assembly is significantly reduced9.5%84
Headlamp aim: projected beam image is obviously incorrect8.4%74
Position lamp: not working8.2%72

Item names are DVSA’s own wording. 2023–2025 combined.

What to check on a 1997 Ford Transit before buying

The three areas where failed first tests most often had a fault, 2023–2025.

  1. Lamps and electrics. Ask someone to watch while you work the brake lights, indicators, sidelights, dipped and main beam, and the number-plate lamps.
  2. Suspension. Worth looking behind the front wheels with a torch at the coil springs, and listening for knocks over bumps on the test drive.
  3. Body and underside. Worth looking underneath with a torch at the sills, floor and mountings for corrosion, and at the rubber boots on the drive shafts for splits.

Common 1997 Ford Transit MOT advisories

Advisories are points the tester noted that did not fail the car. Most common on 1997 Transits, as a share of all 2,360 first tests, 2023–2025.

DVSA advisory itemShare of first testsTests
Engine oil leaks: leak, but not excessive20.5%483
Rigid brake pipes: corroded, covered in grease or other material12.1%285
Wheel bearings: has slight play10.2%240
Component mounting prescribed areas: prescribed area is corroded but not considered excessive9.7%230
Brake discs: worn, pitted or scored, but not seriously weakened8.8%208

Questions about the 1997 Ford Transit MOT

What is the MOT pass rate of a 1997 Ford Transit?

In 2025, 65.0% of Transits first used in 1997 passed their MOT first time, against 66.9% for all cars first used in 1997. A car fixed during the test counts as a fail.

What does a 1997 Transit most often fail its MOT on?

Lamps and electrical equipment (in 45.5% of failed first tests, 2023–2025), suspension (41.2%) and body, chassis and structure (39.8%). The single most common item was “Component mounting prescribed areas: prescribed area excessively corroded significantly reducing structural strength” (25.7%).

How often does a 1997 Ford Transit fail its MOT?

In 2025, 35.0% of first tests on Transits first used in 1997 did not pass first time: 28.8% failed, and a further 6.2% had a fault fixed during the test (counted as a fail here). Across 2023–2025, 880 of 2,360 first tests did not pass first time.

What are the most common 1997 Ford Transit MOT advisories?

“Engine oil leaks: leak, but not excessive” (on 20.5% of first tests, 2023–2025), “Rigid brake pipes: corroded, covered in grease or other material” (12.1%), “Wheel bearings: has slight play” (10.2%), “Component mounting prescribed areas: prescribed area is corroded but not considered excessive” (9.7%) and “Brake discs: worn, pitted or scored, but not seriously weakened” (8.8%).

Is a 1997 Ford Transit reliable?

An MOT pass rate shows what failed at the test, not how reliable a car is. For this group of cars the first-time pass rate went from 61.8% in 2021 to 65.0% in 2025. For one particular car, its own MOT history matters more than the average.

Other cars first used in 1997

The most-tested cars from the same year. Each page uses the same method.

1997 Land Rover Defender MOT statistics · 1997 Volkswagen Transporter MOT statistics · 1997 Mazda MX-5 MOT statistics · 1997 BMW Z3 MOT statistics · 1997 BMW 3 Series MOT statistics

How the 1997 Ford Transit MOT data is calculated

Every number on this page is calculated by SortedCars from DVSA’s anonymised MOT test data for Great Britain, 2021–2025. “1997 Transit” means a Ford Transit whose date of first use falls in 1997 (P and R plates), all trims grouped. Class 4 vehicles, first tests only — retests are not counted. Pass rate = passed ÷ all first tests; a car with a fault fixed during the test (PRS) counts as a fail. Our national first-test pass rate matches DVSA’s published figure (table DVSA/MOT/01) to within 0.04 points in every year. Clean pass = passed with no advisory and no minor defect recorded. Mileage is the reading recorded at the test. Comparisons are with all cars first used in 1997, any make or fuel, and are not adjusted for mileage, fuel or use. Failure and advisory item names are DVSA’s own wording. No figure is shown for fewer than 500 tests; an item is shown only if it appears on at least 50 tests and 1% of the base. Pass rates describe a group of cars, not one car: a well-kept example can pass and a neglected one can fail. This page is general information, not advice about any particular vehicle; always have a used car inspected before you buy. SortedCars is not affiliated with or endorsed by DVSA. You can check any car’s MOT history free on the official service: gov.uk/check-mot-history. Contains public sector information licensed under the Open Government Licence v3.0.